gsxr600充电问题

edichen

白坭华仔 发表于 2013-2-19 20:37
k系的线圈是通病，我帮朋友搞过3部了！注意线圈的引线不要太长，还要套黄蜡管！

换了充电器。然后我朋友有刺灯检查充电器。那刺灯的灯才一点点亮。检查线圈也是一样。郁闷啊。

edichen

白坭华仔 发表于 2013-2-19 20:40
一拆边盖就知道了，有一组变色了，百份百是！

看你贴。你们那好多k系列啊。有没k6的改装排气卖啊。哈哈

比风更快

Suzuki Recalls 70,000+ Motorcycles for Faulty Rectifier
    If you’ve bought a Suzuki motorcycle in the past few years, you might want to check out the list for the Japanese company’s latest motorcycle recall. Affecting 73,426 motorcycles from various product lines and model years (2008-2010), Suzuki has discovered a faulty electrical rectifier/regulator in its design that needs replacing.
    According to the recall, rectifiers/regulators on bikes built between July 2007 and September 2009 have an inadequate amount of adhesion between the power module and the case, which results in the unit not sufficiently being cooled by its heat sink (affected Suzuki part numbers are: 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01). As a result the unit’s circuit board could warp, and become dislodged from its casing.
    Should the rectifier/regulator start malfunctioning because of this condition, the motorcycle would improperly charge its electrical system, likely draining the battery, and possibly causing the motorcycle to stall. Suzuki will notify owners affected by the issue, and a Suzuki distributor will replace the affected part for free. The recall is expected to take place March 2, 2011, the affected models are listed below. Concerned Suzuki owners can contact Suzuki 1-714-996-7040, and as always the NHTSA is available at 1-888-327-4236 or at the safercar.gov website.
Affected Model Affected Model Year
Suzuki / AN400 2008-2009
Suzuki / DL1000 2008-2009
Suzuki / GSF1250 2008-2009
Suzuki / GSX-R600 2008-2009
Suzuki / GSX-R750 2008-2009
Suzuki / GSX1300B 2008
Suzuki / GSX1300R 2008-2010
Suzuki / GSX650F 2008-2009
Suzuki / SFV650 2009-2010
Suzuki / VL800 2008-2010
Suzuki / VLR1800 2008-2009
Suzuki / VZ1500 2009-2010

Source: NHTSA


下面是google提供的翻译:
                                                铃木召回70000+ 摩托车整流器故障

        如果你已经买了，在过去几年里铃木摩托车，您可能想要检查为日本公司的最新摩托车召回名单。从各种影响73426的产品线和（2008-2010）模型年摩托车，铃木发现了一个错误的电整流器的设计，需要更换/稳压器。

        据回忆，整流器/2007年7月之间2009年9月建成自行车监管机构之间的粘附和功率模块的情况下，这不充分，则其散热冷却效果的单位数量不足（受影响铃木部件号：32800-41F11，32800-15H10，3.28万-05H11，32800-41G10，3.28万，15:00，32800，18:00，32800-05G10，32800-10G10，32800-05H20，或32800-06G01）。因此，本单位的电路板可以弯曲，并成为其外壳脱落。

        如果整流/稳压器启动，因为这种情况出现故障，摩托车将其电气系统的不当收费，可能耗尽电池，并可能导致摩托车来搪塞。铃木将通知受影响业主的问题，以及铃木经销商将免费更换受影响的部分。此次召回预计将举行2011年3月2日，受影响的机型如下。有关业主可以铃木铃木1-714-996-7040联系，并将一如既往国家公路交通安全管理局可在1-888-327-4236或在safercar.gov网站。

来源：国家公路交通安全局

edichen

比风更快 发表于 2013-2-19 23:47
Suzuki Recalls 70,000+ Motorcycles for Faulty Rectifier
    If you’ve bought a Suzuki motorcycle  ...

谢谢。不是我们就没办法去更换了。只能靠自己检查。维修了。

edichen

白坭华仔 发表于 2013-2-19 20:37
k系的线圈是通病，我帮朋友搞过3部了！注意线圈的引线不要太长，还要套黄蜡管！

查出来了。今天把线圈拆来看。一拆就看到有1个黑了。

edichen

查出来了。的确线圈被烧。谢谢大家。

大盗

咯咯

1/4油门

可以修复的还好。

waione197

你好,我也是 GSXR 600 车主,我的也充不上电,也是线圈燒黑了,請問你換的是国產定原装拆车线圈? 是否換了就回复正常?

神雕侠侣

看来这车质量不过硬